Product ID:COMPOUND 1077
MSDS Date:08/23/1990
FSC:8010
NIIN:00N056843
MSDS Number: BWNWR

MAGNOLIA PLASTICS INC

5547 PEACHTREE INDUSTRIAL BLVD
CHAMBLEE, GA 30341
US

Emergency Phone: 404-451-2777

Info Phone: 404-451-2777

Cage: 22121

MAGNOLIA PLASTICS INC

CHAMBLEE, GA 30341-2234 US

Telephone: (770) 451-2777/(800) 457-4280

Cage: 22121

ALUMINUM; (ALUMINUM POWDER) (DISPERSED IN LIQUID)

CAS: 7429-90-5

RTECS: BD0330000

Fraction By Weight: 40-50%

OSHA PEL N/K

ACGIH TLV: 5 MG/M3 (MFG)

AMORPHOUS SILICA; (AMORPHOUS FUMED SILICA) (DISPERSED IN

Fraction By Weight: 5-10%

OSHA PEL N/K

ACGIH TLV: 10 MG/M3 (MFG)

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:MODERATELY IRRITATING TO SKIN &
EYES. POSSIBLE SKIN SENSITIZER. CHRONIC:NONE LISTED BY
MANUFACTURER.
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:PRE-EXISTING SKIN & EYE DISORDERS
MAY BE AGGRAVATED.

First Aid:SKIN:REMOVE CONTAMD CLTHG. WASH W/SOAP & WATER. LAUNDER
CLOTHING PRIOR TO RE-USE. EYES:FLUSH W/WATER FOR @ LEAST 15 MINS
WHILE HOLDING EYELIDS OPEN. GET MED ATTN. INHAL:REMOVE VICTIM TO
FRESH AIR. ADM INISTER OXYGEN IF NECESSARY. INGEST:DO NOT INDUCE
VOMIT. GIVE LARGE DOSES OF WATER. GET MEDICAL ATTENTION.

Flash Point Method:PMCC
Flash Point:>200F,>93C
Extinguishing Media:WATER SPRAY, FOAM, DRY CHEMICAL, CO*2.
Fire Fighting Procedures:USE NIOSH/MSHA APPROVED SCBA & FULL PROTECTIVE
EQUIPMENT . AVOID BRTHG SMOKE. COOL FIRE EXPOSED CONTAINER WITH
WATER.
Unusual Fire/Explosion Hazard:NONE.

Spill Release Procedures:AVOID CONT W/LIQUID & VAPORS. WIPE W/CLOTH OR
COLLECT ON ABSORBENT MATL. LARGE SPILLS:DIKE & CONTAIN. PUMP OR
SHOVEL INTO SALVAGE VESSELS.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:WARNING STATEMENTS:FOR INDUSTRIAL USE
ONLY. MAY CAUSE SKIN IRRIT. AVOID CONT W/EYES.
Other Precautions:STORE IN COOL, DRY AREA IN TIGHTLY CLOSED CNTNRS.
AVOID CONT W/SKIN & EYES. USE W/ADEQUATE VENTILATION. USE GOOD
HYGIENE PRACTICES.

Respiratory Protection:FOR EXCESSIVE VAPORS OR TO MAINTAIN BELOW TLV
LIMIT. NIOSH/MSHA APPRVD RESPIRATOR FOR ORGANIC VAPORS IN
COMPLIANCE WITH 29 CFR 1910.134.
Ventilation:LOCAL EXHAUST & MECHANICAL (GENERAL).
Protective Gloves:IMPERVIOUS RUBBER GLOVES.
Eye Protection:ANSI APPROVED SPLASH-PROOF (SUP DAT)
Other Protective Equipment:FOR PRLNGD EXPOS, IMPERVIOUS CLTHG & BOOTS
TO MINIMIZE PERSONAL CONT. ANSI APPRVD EYE-WASH STATION, SFTY
SHOWER .
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER. EYE PROTECTION:CHEMICAL GOGGLES .

Boiling Pt:B.P. Text:>225F,>107C
Vapor Pres:NIL
Vapor Density:>1
Spec Gravity:1.40 (H*2O =1)
Evaporation Rate & Reference:<1 (BUAC = 1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:GRAY PASTE
Percent Volatiles by Volume:0

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONG LEWIS OR MINERAL ACIDS.
Stability Condition to Avoid:ELEVATED TEMPERATURES.
Hazardous Decomposition Products:CO, ALDEHYDES, ACIDS.
Conditions to Avoid Polymerization:REACTION WITH SOME CURING AGENTS IN
BULK AMTS IS EXOTHERMIC.

Waste Disposal Methods:CURE, THEN BURY/INCIN WHERE PERMITTED BY
FEDERAL, STATE AND LOCAL REGULATIONS. REMOVE SALVAGE VESSELS TO
WASTE DISPOSAL SITE OPERATING IN COMPLIANCE WITH FEDERAL, STATE AND
LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.